Product ID:TYPE II WALKWAY, SEAPLANE GRAY, G-8134
MSDS Date:07/26/1990
FSC:8010
NIIN:00-599-9201
MSDS Number: BJMZF

AKRON PAINT AND VARNISH, INC.

1390 FIRESTONE PARKWAY
AKRON, OH 44301-1624
US

Emergency Phone: 216-773-8911

Info Phone: 216-773-8911

Cage: 70228

AKRON PAINT AND VARNISH INC

AKRON, OH 44301-1624 US

Telephone: 216-773-8911

Cage: 70228

ALIPHATIC PETR.DISTILLATES (VP 15 MM HG) (<8% XYLENE) (SARA

CAS: 8030-30-6

RTECS: DE3030000

Fraction By Weight: 20-50%

OSHA PEL 300 PPM

ACGIH TLV: 300 PPM

SILICA, CRYSTALLINE - QUARTZ

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 20-50%

OSHA PEL SEE TABLE Z3

ACGIH TLV: 0.1 MG/M3 RDUST;9293

Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:UNKNOWN IARC:YES
Health Hazards Acute and Chronic:SWALLOWING: ASPIRATION OF MATERIAL
INTO THE LUNGS CAN CAUSE CHEMICAL PNEUMONITIS WHICH CAN BE FATAL.
Explanation of Carcinogenicity:CRYSTALLINE SILICA IS LISTED AS A
CARCINOGEN.
Effects of Overexposure:EYES:MAY CAUSE REDNESS, IRRITATION, SWELLING &
BLURRED VISION. SKIN:PROLONGED/REPEATED CONTACT-MOD IRRITATION,
DEFATT, DERMATITIS. EXCESSIVE INHALE:RESPIRATORY IRRITATION,
DIZZINESS, WEAKNESS, FATIGUE , NAUSEA, HEADACHE, UNCONSCIOUSNESS &
EVEN ASPHYXIATION. SWALLOWING:GASTROINTESTINAL IRRIT, NAUSEA,
VOMITING & DIARRHEA.

First Aid:EYES:FLUSH W/LG AMTS OF WATER 15 MINS, LIFTING LIDS, GET MED
ATTN. SKIN:WASH W/SOAP & WATER, REMOVE CONTAM CLOTHES IMMED & WASH
BEFORE REUSE. SEE DR. IF IRRIT PERSIST. SWALLOW:DO NOT INDUCE
VOMIT! KEE P PERSON WARM, QUIET & GET MED ATTN. ASPIRATION INTO
LUNGS DUE TO VOMIT CAN CAUSE CHEM PNEUMONITIS WHICH CAN BE FATAL.
DRINK 1-2 GLASSES OF WATER. INHALE:MOVE TO FRESH AIR, ADMIN
OXYGEN/CPR AS NEEDED

Flash Point Method:TCC
Flash Point:50 F/10 C
Lower Limits:0.9
Extinguishing Media:CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER FOG. USE
WATER FOR COOLING MATERIAL STORED IN VICINITY OF FIRE.
Fire Fighting Procedures:USE SCBA W/FULL FACEPIECE OPERATED IN
PRESS-DEMAND/OTHER POSITIVE PRESS MODE. WEAR PROTECTIVE CLOTHING.
APPLICATION TO HOT SURFACES REQUIRES SPECIAL PRECAUTIONS
Unusual Fire/Explosion Hazard:VAPOR>THAN AIR MAY TRAVEL BY GROUND,ETC.
TO IGNITE SOURCE DISTANT FROM HANDLING POINT.CONTAIN(EMPTY)MAY
EXPLODE.OVEREXP TO DECOMP, POSSBL DELAYED HEALTH HAZARD

Spill Release Procedures:SM:ABSORB LIQ W/RAGS,ABSORB,VERMICUL,OTHER &
TRANSFER TO HOOD. LG:ELIM IGNITE SOURCES.DIKE AREA.VENT AREA,PUMP
LIQ INTO SALVAGE TANK,REMAIN LIQ TAKE UP W/SAND,FLOOR ABSORB,OTHER
ABSORB & SHOVEL INTO C ONTAINER. PREVENT RUN-OFF TO SEWERS & BODIES
OF*
Neutralizing Agent:N/K. *WATER. NOTIFY PROPER AUTHORITIES AS REQUIRED
BY LOCAL,STATE & FED REGS.

Handling and Storage Precautions:DO NOT DROP CONTAIN.AVOID
HEAT,SPARK,OPEN FLAME. STORE LG AMNT ONLY IN BLDG DESIGNED TO
COMPLY W/OSHA1910.106.NEVER USE PRESS TO EMPTY.AVOID INHALING.
Other Precautions:HOT ORGANIC CHEMICAL VAPORS OR MISTS ARE SUSCEPTIBLE
TO SUDDEN SPONTANEOUS COMBUSTION WHEN MIXED WITH AIR. IGNITION MAY
OCCUR AT TEMPERATURES BELOW THOSE PUBLISHED IN THE LITERATURE AS
"AUTOIGNITION" OR "IGNITION" TEMPERATURES.

Respiratory Protection:IF OUTDOORS OR OPEN AREAS WITH UNRESTRICTED
VENTILATION, APPROVED CHEMICAL/MECHANICAL FILTERS DESIGNED TO
REMOVE A COMBINATION OF PARTICULATES & VAPORS. IN CONFINED AREAS,
APPROVED AIR LINE TYPE RESPI RATORS OR HOODS.
Ventilation:PROVIDE SUFF VENT IN VOL/PATTERN TO KEEP AIR CONTAM
CONCENTRATE BELOW CURRENT APPLICABLE LIMITS. REMOVE DECOMP
PRODUCTS.
Protective Gloves:RESISTANT GLOVES SUCH AS NITRILE RUBBER
Eye Protection:CHEM SPLASH GOGGLES OR OTHERS PERMITED
Other Protective Equipment:NORMAL PROTECTIVE CLOTHING. WASH
CONTAMINATED CLOTHING BEFORE REUSE.
Work Hygienic Practices:OBSERVE ALL PRECAUTIONS. WASH CONTAMINATED
CLOTHING BEFORE REUSE.
Supplemental Safety and Health
CAUTION: THIS PRODUCT CONTAINS PIGMENTS WHICH MAY BECOME A DUST
NUISANCE WHEN REMOVED BY SANDING, ABRADING OR SANDBLASTING. DUST
MASKS SHOULD BE WORN DURING THESE OPERATIONS TO AVOID THIS HAZARD.

Boiling Pt:B.P. Text:240 TO 285F
Vapor Density:> THAN AIR
Spec Gravity:1.35
Evaporation Rate & Reference:6.87 X N-BUTYL ACETATE
Appearance and Odor:SEAPLANE GRAY LIQUID.
Percent Volatiles by Volume:51.0

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZERS (E.G. NITRIC ACID)
Stability Condition to Avoid:KEEP AWAY FROM HEAT AND OPEN FLAME.
Hazardous Decomposition Products:MAY FORM CARBON MONOXIDE AND DIOXIDE,
VARIOUS HYDROCARBONS, ETC.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.